آمار
| تعداد نشریات | 23 |
| تعداد شماره‌ها | 368 |
| تعداد مقالات | 2,890 |
| تعداد مشاهده مقاله | 2,566,171 |
| تعداد دریافت فایل اصل مقاله | 1,821,835 |
End-of-life reverse osmosis membranes: Recycle procedure and its applications for the treatment of brackish and surface water | ||
| Journal of Applied Research in Water and Wastewater | ||
| دوره 8، شماره 1 - شماره پیاپی 15، شهریور 2021، صفحه 77-87 اصل مقاله (1.61 M) | ||
| نوع مقاله: Research Paper | ||
| شناسه دیجیتال (DOI): 10.22126/arww.2021.6499.1214 | ||
| نویسندگان | ||
| Fábio Ivan Ivan Seibel1؛ Guilherme Otávio Moraes Giubel Giubel1؛ Vandré Barbosa Brião* 1؛ Mehri Shabani2؛ Maxime Pontié3 | ||
| 1University of Passo Fundo, Faculty of Engineering and Architecture, Rio Grande do Sul, Brazil. | ||
| 2École d’ingénieur Informatiqueet Environnment (ESAIP), Saint-Barthélemy d’Anjou, France. | ||
| 3University of Angers, Faculty of Sciences, Group Analysis & Processes, Angers, France. | ||
| چکیده | ||
| As a result of population growth and potable water scarcity, an increasing number of reverse osmosis desalination plants are being installed and operated (more than 15,000 in the world). Reverse osmosis membranes tend to reach the end of the life cycle in around two to five years, becoming a solid waste. Recycling/repurposing these aged membranes could be a sustainable and profitable solution. This project aimed to transform end-of-life reverse osmosis membranes through the oxidation of their active layer using chlorine into nanoporous/microporous membranes, while searching possible applications for the resulting membranes. The results show that membranes oxidized at 10,000 ppm.h had a significant increase in permeability (3.1x), reaching NF-like capacity. On the other hand it was observed a decrease in the rejection of salt (4.35x) and acetaminophen (1.5x). Scanning Electron Microscopy (SEM) shows the positive effect of chlorine in the complete removal of particles deposited over the membrane. This oxidation condition also increased the average roughness (2.42x) of the membrane, as shown by Atomic Force Microscopy (AFM). Analysis by Fourier Transform Reflectance Spectroscopy (FTIR) suggests that chlorine oxidation replaced the hydrogen in the amide nitrogen. Both FTIR and SEM suggests the polyamide layer was not fully degraded. Application tests suggests that the recycled membrane can be used for the treatment of brackish and surface waters. The recycling of reverse osmosis membranes can be an alternative to simple landfill disposal, allowing owners to shift from disposal cost to revenue, as well as being a sustainable solution. The high permeability achieved on these oxidized membranes suggest many other NF/UF functions could potentially use recycled RO membranes. | ||
| کلیدواژه‌ها | ||
| Reverse osmosis؛ Membrane recycling؛ Oxidation؛ Desalination؛ Membrane second life؛ Nanofiltration | ||
| مراجع | ||
|
Acero J. L. Benitez J. F., Teva F., Leal A. I., Retention of emerging micropollutants from UP water and a municipal secondary effluent by ultrafiltration and nanofiltration, Chemical Engineering Journal 163 (2010) 264-272. Aghababaei N. Reverse osmosis design with IMS design software to produce drinking water in Bandar Abbas Iran, Journal of Applied Research in Water and Wastewater 4 (2017) 314-318. Antony A., Branch A., Leslie G., Le-Clech P., Impact of membrane ageing on reverse osmosis performance – Implications on validation protocol, Journal of Membrane Science 520 (2016) 37-44. Azaïs A., Mendret J., Petit E., Brosillon S., Evidence of solute-solute interactions and cake enhanced concentration polarization during removal of pharmaceuticals from urban wastewater by nanofiltration, Water Research 104 (2016) 156-167. Benavente J., Vázquez, M. I., Effect of age and chemical treatments on characteristic parameters for active and porous sublayers of polymeric composite membranes, Journal of Colloid and Interface Science 273 (2004) 547-555. Boulahfa H., Belhamidi S., Elhannouni F., Taky Mohamed., El Fadil A., Elmidaoui A., Demineralization of brackish surface water by reverse osmosis: The first experience in Morocco, Journal of Environmental Chemical Engineering 7 (2019) 1-9. Cohen-Tanugi D., McGovern R. K., Dave J. H., Grossman J. C., Quantifying the potential of ultra-permeable membranes for water desalination, Energy and Environmental Science 7 (2014) 1134-1141. Daneshvar A., Svanfekt J., Kronberg L., Prévost M., Weyhenmeyer G. A., Seasonal variations in the occurrence and fate of basic and neutral pharmaceuticals in a Swedish river-lake system, Chemosphere 80 (2010) 310-309. Do V. T., Tang C. Y., Reinhard M., Leckie J. O., Effects of chlorine exposure conditions on physiochemical properties and performance of a polyamide membrane-mechanisms and implications, Environmental Science and Technology 46 (2012) 13184-13192. Donose B. C., Sukumar S., Pidou M., Poussade Y., Keller J., Gernjak W., Effect of pH on the ageing of reverse osmosis membranes upon exposure to hypochlorite, Desalination 309 (2013) 97-105. Ettori A., Gaudichet-Maurin E., Schrotter J. C., Aimar P., Causserand C., Permeability and chemical analysis of aromatic polyamide based membranes exposed to sodium hypochlorite, Journal of Membrane Science 375 (2011) 220-230. García-Pacheco R., Landaburu-Aguirre J., Lejarazu-Larrañaga A., Rodríguez-Sáez L., Molina S., Ransome T., García-Calvo E., Free chlorine exposure dose (ppm·h) and its impact on RO membranes ageing and recycling potential, Desalination 457 (2019) 133-143. Ge S., Feng L., Zhang L., Xu Q., Yang Y., Wang Z., Kim K. H., Rejection rate and mechanisms of drugs in drinking water by nanofiltration technology, Environmental Engineering Research 22 (2017) 329-338. Geissen V., Mol H., Klumpp E., Umlauf G., Nadal N., Ploeg M. V. D., Zee S. E. A. T. M. V. D., Ritsema C. J., Emerging pollutants in the environment: A challenge for water resource management, International Soil and Water Conservation Research 3 (2015) 57-65. Goodship V., Introduction to Plastics Recycling Second, Smithers Rapra Technology Limited, Second ed., Shawbury: United Kingdom; (2007). Guo W., Ngo H. H., Li J., A mini-review on membrane fouling, Bioresource Technology 122 (2012) 27-34. Heidarzadeh M., Abdi N., Varvani Farahani J., Ahmadi A., Toranjzar H., The effect of Typha Latifolia L. heavy metals phytoremediation at the urban wastewater entrance to the Meighan wetland, Journal of Applied Research in Water and Wastewater 7 (2020) 167-171. Hibbs M. R., McGrath L. K., Kang S., Adout A., Altman S. J., Elimelech M., Cornelius C. J., Designing a biocidal reverse osmosis membrane coating: Synthesis and biofouling properties, Desalination 380 (2016) 52-59. Kwon Y. N., Leckie J. O., Hypochlorite degradation of crosslinked polyamide membranes. I. Changes in chemical/morphological properties, Journal of Membrane Science 283 (2006) 21-26. Kwon, Y. N., Tang, C. Y. and Leckie, J. O., Change of membrane performance due to chlorination of crosslinked polyamide membranes, Journal of Applied Polymer Science 102 (2006) 5895-5902. Lawler W., Antony A., Cran M., Duke M., Leslie G., Le-Clech P., Production and characterisation of UF membranes by chemical conversion of used RO membranes, Journal of Membrane Science 447 (2013) 203-211. Lawler W., Bradford-Hartke Z., Cran M. J., Duke M., Leslie G., Ladewig B. P., Le-Clech P., Towards new opportunities for reuse, recycling and disposal of used reverse osmosis membranes, Desalination 299 (2012) 103-112. Licona K. P. M., Geaquinto L. R. O., Nicolini J. V., Figueiredo N. G., Chiapetta S. C., Habert A. C., Yokoyama L., Assessing potential of nanofiltration and reverse osmosis for removal of toxic pharmaceuticals from water, Journal of Water Process Engineering 25 (2018) 195-204. Lilane A., Saifaoui D., Hariss S., Jenkal H., Chouiekh M., Modeling and simulation of the performances of the reverse osmosis membrane, Materials Today: Proceedings 24 (2019) 114-118. Liu M., Yu S., Tao J., Gao C., Preparation, structure characteristics and separation properties of thin-film composite polyamide-urethane seawater reverse osmosis membrane, Journal of Membrane Science 325 (2008) 947-956. Mbokou S. F., Pontié M., Bouchara J. P., Tchieno F. M. M., Njanja E., Mogni A., Pontalier P. Y., Tonle I. K., Electroanalytical Performance of a Carbon Paste Electrode Modified by Coffee Husks for the Quantification of Acetaminophen in Quality Control of Commercialized Pharmaceutical Tablets, International Journal of Electrochemistry 2016 (2016) 10. Mutiyar P. K., Gupta S. K., Mittal A. K., Fate of pharmaceutical active compounds (PhACs) from River Yamuna, India: An ecotoxicological risk assessment approach, Ecotoxicology and Environmental Safety 150 (2018) 297-304. Nejati S., Mirbagheri S. A., Warsinger D. M., Fazeli M., Biofouling in seawater reverse osmosis (SWRO): Impact of module geometry and mitigation with ultrafiltration, Journal of Water Process Engineering 29 (2019) 1-7. Okamoto Y., Lienhard J. H., How RO membrane permeability and other performance factors affect process cost and energy use: A review, Desalination 470 (2019) 1-21. Oulad F., Zinatizadeh A. A.,Derakhshan A. A., Purification performance evaluation of licorice aqueous solution using modified nanofiltration membrane, Journal of Applied Research in Water Wastewater 5 (2) (2019) 431-434. Ould Mohamedou E., Suarez D. B. P., Vince F., Jaouen P., Pontié M., New lives for old reverse osmosis (RO) membranes, Desalination 253 (2010) 62-70. Pontié M., Awad S., Tazerout M., Chaouachi O., Chaouachi B., Recycling and energy recovery solutions of end-of-life reverse osmosis (RO) membrane materials: A sustainable approach, Desalination 423 (2017) 30-40. Pontié M., Old RO membranes: solutions for reuse, Desalination and Water Treatment 53 (2015) 1492-1498. Pype M. L., Lawrence M. G., Keller J., Gernjak W., Reverse osmosis integrity monitoring in water reuse: The challenge to verify virus removal - A review, Water Research 98 (2016) 385-395. Radjenović J., Petrovic M., Ventura F., Barceló D., Rejection of pharmaceuticals in nanofiltration and reverse osmosis membrane drinking water treatment, Water Research 42 (2008) 3601-3610. Reyes-Contreras C., Leiva A. M., Vidal G., Evaluation of triclosan toxic effects on the methanogenic activity, Electronic Journal of Biotechnology 39 (2019) 61-66. Rodríguez J. J., Jiménez V., Trujillo O., Veza J. M., Reuse of reverse osmosis membranes in advanced wastewater treatment, Desalination 150 (2002) 219-225. Ruiz S. G., López-Ramírez J. A., Zerrouk M. H., Lopero A. E. C., Alonso J. M. Q., Study of reverse osmosis membranes fouling by inorganic salts and colloidal particles during seawater desalination, Applied Catalysis B, Environmental 118224 (2019) 733-742. Sacher F., Lange F. T., Brauch H. J., Blankenhorn I., Pharmaceuticals in groundwaters: Analytical methods and results of a monitoring program in Baden-Württemberg, Germany, Journal of Chromatography A 938 (2001) 199-210. Sahinkaya E., Tuncman S., Koc I., Guner A. R., Ciftci S., Aygun A., Sengul S., Performance of a pilot-scale reverse osmosis process for water recovery from biologically-treated textile wastewater, Journal of Environmental Management 249 (2019) 1-8. Sim L. N., Chong T. H., Taheri A. H., Sim S. T. V., Lai L., Krantz W. B. Fane A. G., A review of fouling indices and monitoring techniques for reverse osmosis, Desalination 434 (2018) 169-188. Simon A., Nghiem L. D., Le-Clech P., Khan S. J., Drewes J. E., Effects of membrane degradation on the removal of pharmaceutically active compounds (PhACs) by NF/RO filtration processes, Journal of Membrane Science 340 (2009) 16-25. Sørup H. J. D., Brudler S., Godskesen B., Dong Y., Lerer S. M., Rygaard M., Arnbjerg-Nielsen K., Urban water management: Can UN SDG 6 be met within the Planetary Boundaries?, Environmental Science and Policy 106 (2020) 36-39. Taheran M., Naghdi M., Brar S. K., Verma M., Surampalli R. Y., Emerging contaminants: Here Today, There Tomorrow!, Environmental Nanotechnology, Monitoring & Management 10 (2018) 122-126. Terrero P., García-Pacheco R., Campos-Pozuelo E., Rabadán F. J., Molina-Martínez S., de Lajarazu A. O., Zarzo-Martínez D., Transformation of end-of-life RO membrane into recycled NF and UF membranes: Results of the transformation process and its validation at pilot scale, IDA15WC (2015) 1-18. Veras T. B., Paiva A. L. R., Duarte M. M. M. B., Napoleão D. C., Cabral J. J. S. P., Analysis of the presence of anti-inflammatories drugs in surface water: A case study in Beberibe river-PE, Brazil., Chemosphere 222 (2019) 961-969. Veza J. M., Rodriguez-Gonzalez J. J., Second use for old reverse osmosis membranes: Wastewater treatment, Desalination 157 (2003) 65-72. Warsinger D. M., Chakraborty S., Tow E. W., Plumlee M. H., Bellona C., Loutatidou S., Karimi L., Mikelonis A. M., Achilli A., Ghassemi A., Padhye L. P., Snyder S. A., Curcio S., Vecitis C. D., Arafat H. A., Lienhard J. H., A review of polymeric membranes and processes for potable water reuse, Progress in Polymer Science 81 (2018) 209-237. Wiegel S., Aulinger A., Brockmeyer R., Harms H., Löffler J., Reincke H., Schmidt R., Stachel B., Tümpling W. V., Wanke A., Pharmaceuticals in the river Elbe and its tributaries, Chemosphere 57 (2004) 107-126. Zaidi S. M. J., Fadhillah F., Khan Z., Ismail A. F., Salt and water transport in reverse osmosis thin film composite seawater desalination membranes, Desalination 368 (2015) 202-213. Zou H., Jin Y., Yang J., Dai H., Yu X., Xu J., Synthesis and characterization of thin film composite reverse osmosis membranes via novel interfacial polymerization approach, Separation and Purification Technology 72 (2010) 256-262. | ||
|
آمار تعداد مشاهده مقاله: 690 تعداد دریافت فایل اصل مقاله: 1,023 |
||